Snorkel TB66J User Manual Page 66
- Page / 84
- Table of contents
- TROUBLESHOOTING
- BOOKMARKS
Rated. / 5. Based on customer reviews
Chapter 9 – Stowing and Transporting
62 TB66J – 0083740
3. Raise the main boom about 1′ (0.3 m).
4. Place a wood block under the rotator pylon. Lower
the boom so the pylon rests on the wood block.
5. From the upper controls, turn the start switch to the
off position. If equipped, place the platform control
box cover over the upper controls.
6. From the lower controls, push the emergency stop
button inward. Turn the start switch to the off position
and remove the key.
7. Turn the battery disconnect switch off.
8. On duel fuel machines, close the shut-off valve on
the LPG tank (refer to Figure 9.5).
Figure 9.5 – LPG Tank
9. Close and latch the cowling doors.
Figure 9.6 – Platform
Steel
Aluminum
10. Use wire-ties to fasten the platform gate to the
guardrails to prevent the gate from bouncing. Also,
use wire-ties to fasten the platform foot switch to
the platform oor.
Caution
Ratchets, winches, and come-alongs may produce
enough force to damage machine components. Do
not over tighten the straps or chains when securing
the aerial platform to the transport vehicle.
11. Determine if the platform is made of steel or alu-
minum. Steel platforms have toeboards with rolled
edges an aluminum platforms have toeboards with
straight edges.
Caution
Aluminum toeboards are not strong enough to use
when securing the platform to the transport vehicle.
Damage to the platform may occur if the nylon strap
is placed over the toeboards. Thread the strap
through the platform mounting bracket or over the
mid rail when securing an aluminum platform.
12.
Use a nylon strap to securely fasten the platform
against the wood block. On steel platforms, thread
the strap over the toeboard as shown in Figure 9.7.
13. On aluminum platforms, thread the strap over the
platform mounting bracket or the mid rail as shown
in Figure 9.6.
14. Use chains or straps to securely fasten the aerial
platform to the transport vehicle using the tie-down
lugs as attachment points. Proper tie-down and
hauling are the responsibility of the carrier.
Shutoff Valve
- OPERATOR’S 1
- Table of Contents 3
- Chapter 8 – Operation 4
- Chapter 11 – Troubleshooting 4
- Chapter 1 – Introduction 5
- Maintenance 6
- Manual of Responsibilities 6
- Additional Information 6
- Chapter 3 – Specications 7
- Working Envelope 8
- General Specications 9
- Engine Specications 10
- Engine Oil Viscosity 12
- TB66J – 0083740 9 13
- Chapter 2 – Specications 14
- Chapter 3 – Safety 15
- Prestart Inspection 16
- Operation 16
- Electrical System 17
- Hydraulic System 17
- Tip-Over and Falling Hazards 17
- Placards and Decals 18
- Chapter 4 – Safety Devices 19
- Emergency Lowering Knob 20
- Ground Operation Switch 20
- Platform Foot Switch 20
- Guardrails 20
- Lanyard Anchors 20
- Tilt Alarm 21
- Engine Protection Systems 21
- Flashing Light 22
- Light Switch 22
- Engine Oil 24
- Hydraulic Fluid Filter Gauge 24
- Chapter 6 – Controls 25
- Circuit Breaker Reset Buttons 28
- Upper Controls 28
- Machine/Generator Switch 31
- Horn Button 32
- Operator’s Manual 33
- Fan Belt 34
- Air Intake 34
- Fuel Gauge 34
- TB66J – 0083740 31 35
- Cables and Wiring Harness 36
- Tires and Wheels 37
- Emergency Lowering 38
- Lower Control Station 38
- Level Sensor 39
- Sandblast Protection Kit 40
- Structures 40
- Upper Control Station 41
- Emergency 42
- Stop Button 42
- Engine/Emergency 42
- Power Switch 42
- Start Switch 42
- All Motion Alarm 43
- Air Line to Platform 43
- Platform Glazier Package 44
- Platform Control Cover 44
- Right Side 45
- WA R N IN G 46
- DO NOT RIDE IN PLATFORM 47
- WHILE UNIT IS BEING TOWED 47
- Left Side 48
- D A N G E R 49
- 46 TB66J – 0083740 50
- Prestart Inspection Checklist 51
- 48 TB66J – 0083740 52
- Preparing for Operation 54
- Lower Controls 54
- Four Wheel Drive 57
- Gradeability 57
- Percent of 58
- Angle of Slope 58
- Electrical Power Outlet 59
- AC Generator 59
- Dual Fuel 60
- Air Line 60
- Driving Lights 60
- Platform Work Lights 60
- Bump Guard System 61
- Transporting 63
- Tie-Down 64
- Disconnect Plate 64
- Lifting Lugs 65
- Shutoff Valve 66
- Emergency Power System 67
- 66 TB66J – 0083740 70
- 68 TB66J – 0083740 72
- TB66J – 0083740 69 73
- 70 TB66J – 0083740 74
- Bleeder Valve 75
- Fuel Filter 75
- Bleeder Pump 75
- Fuel Line 75
- Appendix A – Glossary 77
- Appendix A – Glossary 78
- Product Warranty 79
Related products and manuals for Special machinery Snorkel TB66J
Special machinery Snorkel TB85J User Manual
(76 pages)
(76 pages)
© 2020, manymanuals.com. All rights reserved. | 1.120 s |
Manymanuals.com
Manymanuals.de
Manymanuals.fr
Manymanuals.it
Manymanuals.pl
Manymanuals.cz
Manymanuals.es
Manymanuals-pt.com
Comments to this Manuals